Product ID:E61 R 500 KEM AQUA WATER REDUCIBLE PRIMER, RED OXIDE
MSDS Date:07/25/1988
FSC:8010
NIIN:00F032610
MSDS Number: BSZXF

SHERWIN-WILLIAMS CO

101 PROSPECT AVE N W
CLEVELAND, OH 44115-1042
US

Emergency Phone: 216-566-2917

Info Phone: 216-566-2902

Cage: 54636

SHERWIN-WILLIAMS CO THE

CLEVELAND, OH 44115-1042 US

Telephone: 800-251-2486/216-566-2242

Cage: 54636

SILICA DIOXIDE, CRYSTALLINE QUARTZ, SAND (SUSPECTED HUMAN

CAS: 14808-60-7

RTECS: VV7330000

Fraction By Weight: 15%

ACGIH TLV: 0.1 MG/CUM RESP DUST

TALC (POWDER), (ASBESTOS FREE), TALCUM; HYDROUS MAGNESIUM

CAS: 14807-96-6

RTECS: WW2710000

Fraction By Weight: 15%

ACGIH TLV: 2 MG/CUM (RESP DUST)

TITANIUM DIOXIDE, TIO2

CAS: 13463-67-7

RTECS: XR2275000

Fraction By Weight: 0-5%

OSHA PEL 15 MG/CUM

ACGIH TLV: 10 MG/CUM (DUST)

11.1-11.2

RTECS: 9999999WG

2-BUTOXYETHANOL (ETHYLENEGLYCOL MONOBUTYL ETHER), BUTYL

CAS: 111-76-2

RTECS: KJ8575000

Fraction By Weight: 10%

OSHA PEL 50 PPM (SKIN)

ACGIH TLV: 25 PPM (SKIN)

Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:IRRITATION OF EYES, SKIN & UPPER
RESPIRATORY SYSTEM. ALCOHOLS & ACETATES CAN BE ABSORBED THROUGH
SKIN. LONG TERM EXPOSURE TO CRYSTALLINE SILICA MAY CAUSE LUNG
DAMAGE (SILICOSIS) & POSSIBLY CANCER. PRO LONGED OVEREXPOSURE TO
SOLVENTS MAY CAUSE ADVERSE AFFECTS TO LIVER, URINARY & BLOOD
FORMING SYSTEMS.
Explanation of Carcinogenicity:SEE INGREDIENTS
Effects of Overexposure:INHALATION: HEADACHE, NAUSEA, DIZZINESS.
EYES/SKIN: REDNESS, ITCHING, BURNING SENSATION.

First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. KEEP WARM
& QUIET. SKIN: WASH W/SOAP & WATER. EYES: FLUSH W/PLENTY OF WATER
FOR 15 MINS. OBTAIN MEDICAL ATTENTION IN ALL CASES.

Flash Point Method:PMCC
Flash Point:>199F
Extinguishing Media:CO2, DRY CHEMICAL, ALCOHOL FOAM
Fire Fighting Procedures:WEAR FULL PROTECTIVE EQUIPMENT INCLUDING SCBA.
WATER SPRAY MAY BE INEFFECTIVE, BUT MAY BE USED TO COOL CLOSED
CONTAINERS. FOG NOZZLES ARE PREFERRED.
Unusual Fire/Explosion Hazard:WATER MAY BE USED TO COOL CLOSED
CONTAINERS TO PREVENT PRESSURE BUILD-UP & POSSIBLE AUTOIGNITION OR
EXPLOSION WHEN EXPOSED TO EXTREME HEAT.

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE &
REMOVE W/INERT ABSORBENT.

Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE.
TRANSFER ONLY TO APPROVED CONTAINER W/COMPLETE & APPROPRIATE
LABELING. DON'T INCINERATE CLOSED CONTAINERS.
Other Precautions:USE ONLY W/ADEQUATE VENTILATION. AVOID BREATHING
VAPOR & SPRAY MIST. AVOID CONTACT W/SKIN & EYES. KEEP OUT OF REACH
OF CHILDREN.

Respiratory Protection:WEAR PROPERLY FITTED ORGANIC VAPOR/PARTICULATE
RESPIRATOR APPROVED BY NIOSH/MSHA. WHEN
SANDING/WIREBRUSHING/ABRADING/BURNING/WELDING DRIED FILM, WEAR AN
APPROVED PARTICULATE RESPIRATOR FOR PROTECTION AGAINST
NON-VOLATILE MATERIALS. SEE SUPP
Ventilation:LOCAL EXHAUST PREFERABLE. GENERAL EXHAUST ACCEPTABLE.
MAINTAIN EXPOSURE BELOW APPLICABLE EXPOSURE LIMITS
Protective Gloves:AS REQUIRED
Eye Protection:SAFETY GLASSES W/UNPERFORATED SIDESHIELD
Work Hygienic Practices:RMEOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
THIS COATING MAY CONTAIN MATERIALS CLASSIFIED AS NUISANCE PARTICULATES,
SUCH AS TITANIUM DIOXIDE OR CALCIUM CARBONATE, WHICH MAY BE PRESENT
AT HAZARDOUS LEVELS ONLY DURING SANDING OR ABRADING THE DRIE D
FILM.

Boiling Pt:B.P. Text:212-340F
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:60-62

Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:IGNITION SOURCES
Hazardous Decomposition Products:CO2 & CO

Waste Disposal Methods:WASTE FORM THIS PRODUCT MAY BE HAZARDOUS AS
DEFINED UNDER RCRA. WASTE MUST BE TESTED FOR EXTRACTABILITY TO
DETERMINE APPLICABLE EPA HAZARDOUS WASTE NUMBERS. INCINERATE IN
APPROVED FACILITY IAW FEDERAL , STATE & LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.